Products:
New Product Archive
Steel Cushion, 6T40 3-5-Reverse Clutch 2008-Up
Transtar Part Number: 144127
This waved clutch cushion is often broken, causing hard shifts and possible DTC P0776. When replacing this cushion, the 3-5-reverse clutch piston should also be replaced with the updated piston (Transtar part number 144966). The updated piston is included in the Transtar master kits.
Bushing Tools, AW55-50SN and VW 09G Transmissions
Transtar Part Number: T-89428RK
Transtar now offers a new tool to remove and install the bushings in AW55-50SN and VW 09G transmissions. This kit contains the remover and installer tools, as well as a set of bushings and canisters for rebuilding the linear solenoids.
Mag-Hytec Finned Aluminum Deep Pan, 727, 518, 48RE
Transtar Part Number: A22765C
- Deep high-capacity sump for maximum cooling
- Magnetic drain plug
- 1/8 NPT temperature sender port
- Finned aircraft aluminum construction
Transmission Mount, Ford Explorer/Mercury Mountaineer, 2002-2006
Transtar Part Number: MT1043
This common transmission mount is for Ford/Mercury applications. Make sure to keep an eye on this page for more upcoming transmission and engine mounts!6T75 6-Speed FWD Transmission (3.6 Liter, 08 Buick Enclave)
Transtar Part Number: 124-UAA
Remanufactured in the U.S.A. and with the latest OE upgrades, this 6-speed FWD transmission is used in many GM applications. With Transtar's new Premium PLUS Protection (P3) warranty options, the 124-AAB comes standard with a 36-month/100,000-mile nationwide warranty, which can be upgraded to a 36-month/500,000-mile nationwide warranty.Warning:
- Installers must reflash the PCM and follow the proper programming sequence prior to the vehicle being driven. Refer to the install sheet for detailed instructions. If not performed correctly, unit damage could result and may not be covered under warranty.
Bushing and Canister Tools, AW55-50SN and VW 09G Transmissions
Transtar Part Numbers: T-35199 and T-89428RK
Transtar now offers new tools to remove and install canisters and bushings in AW55-50SN and VW 09G transmissions. These kits contains everything needed to replace the bushings and the canisters in the linear solenoids. Also available is Transtar part number 89033-25, which is a pack of 25 new bushings.
Filter (Honda)
Transtar Part Number: A30010L
Transtar part number A30010L is the latest addition to the Honda filter line. This filter fits the CR-V and Element years 2007-Up, four-cylinder Accord years 2008-Up, and the four-cylinder Acura TSX years 2009-11.
Ford 6F50 / 6F55 Low Stall Torque Converter, 07-12
Transtar Part Number: FM1241
Transtar stocks the Recon True Blue Certified rebuilt Ford 6F50 / 6F55 low stall torque converter for applications 07-12. This tested torque converter has three pads, the 18 vane stator, carbon woven clutch lining, and is backed by Transtar's 3-year, 36,000-mile warranty.
6T75 6-Speed AWD Transmission (3.6 Liter, 08 Buick Enclave)
Transtar Part Number: 124-AAB
Remanufactured in the U.S.A. and with the latest OE upgrades, this 6-speed AWD transmission is used in many GM applications. With Transtar's new Premium PLUS Protection (P3) warranty options, the 124-AAB comes standard with a 36-month/100,000-mile nationwide warranty, which can be upgraded to a 36-month/500,000-mile nationwide warranty.
Warning:
- Installers must reflash the PCM and follow the proper programming sequence prior to the vehicle being driven. Refer to the install sheet for detailed instructions. If not performed correctly, unit damage could result and may not be covered under warranty.
Transmission Mount, Universal, GM
Transtar Part Number: 2000
This common transmission mount is for applications 55-97. Make sure to keep an eye on this page for more upcoming transmission and engine mounts!
42RLE External Repair Kit for Wiring Harness 03-05
Transtar Part Number: D162445BK
Vehicles with the 42RLE transmission may come into your shop with multiple codes, including; P0750 LR, P0755 2-4, P0760 OD, P0765 UD, P0846 2-4 PSW, P0871 OD PSW, and P0841 LR PSW. The D162445BK fixes the common issue of water entering the connector and corroding the connectors. This kit comes complete with a new connector plug, pins wires and shrink wrap tubing.
GM 6T70E/6T75E Low Stall Torque Converter, 2007-2011
Transtar Part Number: GM1241
Transtar stocks the rebuilt torque converter for GM 6T70 & 6T75 applications, years 2007 through 2011. Featuring a 3-year, 36,000-mile warranty, this Recon True Blue Certified torque converter is remanufactured using cutting-edge technology and exacting standards.
Filter, RE0F10A (JF011E) Nissan 07-Up (.950" Pickup)
Transtar Part Number: A33010NA
Transtar part number A33010NA is the Nissan version filter for the Jatco JF011E. Nissan refers to this CVT as the RE0F10A. This filter is used in the 2007-Up 2.5L Altima, 2007-Up Sentra, and the 2008-Up Rogue CUV. This filter is similar to the Mitsubishi and Chrysler filter, except it has a longer fluid pick-up pipe.
4F27E FWD Transmission, 2.0L (2010-2011 Ford Transit Connect)
Transtar Part Number: 48-AAX
Remanufactured in the U.S.A. and with the latest OE upgrades, this 4-speed FWD transmission is used in Ford delivery van applications. With Transtar's new Premium PLUS Protection (P3) warranty options, the 48-AAX comes standard with an 18-month/18,000-mile nationwide warranty, which can be upgraded to either a 36-month/100,000-mile or 36-month/500,000-mile nationwide warranty.
Filter, Aisin TF60SN Mini Cooper 2006-Up
Transtar Part Number: A15010D
This new filter for the Aisin TF60 is the fifth version that Transtar offers. Part number A15010D is for the TF60 6-speed automatic used in the Mini Cooper models that do not use the CVT transaxle. The other four versions of TF60 filters are used in various VW models.
Honda 4 & 5-Speed Oversized Clutch Pressure Control Valve & End Plug
Transtar Part Number: S80741S-1
This oversized valve and end plug assembly is for use in a long list of Honda 4 and 5-speed transmissions. The top accumulator valve body uses one, while the servo valve body uses two. This valve affects torque converter function, and is an addition to the Transtar DNA™ listing for torque converter part numbers HO79, HO80, HO82, and HO3001.
Notes:
- Saturn Vue 2004-2007 uses HO82
- Requires the use of special tool part number T-F-98890-TL23 to modify valve body to accept the oversized valve assembly
04-05 Chevrolet/GMC; K2500/K3500 6.6L Duramax Engine 4WD, Allison 1000 Series
Transtar Part Number: 121-TAF
Now available is a popular heavy-duty transmission in the Chevrolet & GMC product line. Remanufactured in the U.S.A. and with the latest OE upgrades, the 121-TAF is backed by the Transtar Seal of Quality. With Transtar's new Premium PLUS Protection (P3) warranty options, this transmission comes standard with an 18-month/18,000-mile nationwide warranty, which can be upgraded to either a 36-month/100,000-mile or 36-month/500,000-mile nationwide warranty.
Filter, AW55-50 Chevy Equinox 05-09
Transtar Part Number: A89010E
Due to the many different vehicles that use the AW55-50 transaxle, A89010E is the third filter for this transmission family. It fits the Chevy Equinox from 2005-09. Not only is the external shape of A89010E different than the other two AW55-50 filters, but it has a felt filter media instead of the screen used in the other two filters.
Ford Planet Package, 4R75W 2004-Up (Updated)
Transtar Part Number: D76583D
Transtar now offers an updated complete planet package for the 4R75W.
Included in this package: planet, sungear, non-magnetic shell, ring gear, direct drum, OEM filter, gasket kit, two bearings, rings, and seals
Solenoid EPC, A4CF1/2 06-Up
Transtar Part Number: D82431D
Transtar now offers the OEM EPC solenoid for the A4CF1/2 transmission family!
Case Connector with Harness, A4CF1/2 06-Up
Transtar Part Number: D82444E
Now available is the case connector for the A4CF1/2 transmission family. This product has a ribbon harness that connects to the internal harness.
Harness Internal, A4CF1/2 06-Up
Transtar Part Number: D82446E
Transtar now offers the wire harness for the A4CF1/2 transmission family. This product has a ribbon harness that connects to the internal solenoids.
Filter, Ford 6R140 2011-Up
Transtar Part Number: 126010
Transtar now stocks the sump filter for the Ford 6R140, which is manufactured by Filtran! The 6R140 is a heavy-duty 6-speed rear-wheel drive transmission used in Ford trucks beginning in 2011.
5-Speed U151E Transmission (2007-2009 Toyota Sienna FWD)
Transtar Part Number: 27-DAF
Remanufactured in the U.S.A. and with the latest OE upgrades, this popular FWD transmission is backed by the Transtar Seal of Quality. With Transtar's new Premium PLUS Protection (P3) warranty options, the 27-DAF comes standard with an 18-month/18,000-mile nationwide warranty, which can be upgraded to either a 36-month/100,000-mile or 36-month/500,000-mile nationwide warranty.
Cooler Line Clip, 1/2", 68RFE
Transtar Part Number: 72496C
If the cooler line clip for the 68RFE is lost or broken, simply call Transtar. Transtar now offers its replacement!
Bushing Bell Housing (Pump) 6L50/80/90
Transtar Part Number: 104034
Now available is a replacement Teflon coated pump bushing. This pump bushing is used in 6L50, 6L80 and 6L90 transmissions.
Filter, Toyota AB60E/F, 2007-Up
Transtar Part Number: A157010
Transtar part number A157010 is the internal sump filter for AB60E and F 6-speed automatic transmissions. These transmissions are used in the 2007-up Toyota Tundra and 2008-up Land Cruiser, Sequoia and Lexus LX570.
6-Speed Automatic 09G Transmission (2003-2005 Volkswagen Beetle, Convertible)
Transtar Part Number: 15-AAB
Transtar now offers the 15-AAB. Remanufactured in the U.S.A. and with the latest OE upgrades, this popular FWD transmission is backed by the Transtar Seal of Quality. With Transtar's new Premium PLUS Protection (P3) warranty options, the 15-AAB comes standard with an 18-month/18,000-mile nationwide warranty, which can be upgraded to either a 36-month/100,000-mile or 36-month/500,000-mile nationwide warranty.
Line Pressure Adapter Tool
Transtar Part Number: T-8259
Transtar offers a line pressure adapter tool for 45RFE/545RFE/68RFE applications. This tool allows you to verify scan tool readings by testing the line pressure in the vehicle.
Master Kit with Steels, GM 6T40 2008-Up
Transtar Part Number: 144006
Transtar part number 144006 is a master kit with steels for the 6T40 FWD transaxle. This kit includes all the gaskets and seals, OEM friction clutches, OEM bonded rubber clutch pistons, and the steel clutch plates necessary to rebuild the transaxle. Also available is Transtar part number 144004, which is the master kit without the steel plates.
Honda/Acura Lube Kit From Transgo
Transtar Part Number: T80168A
The Honda/Acura lube kit from Transgo improves lube flow, and prevents converter overheating for various 4-speeds.
FWD Transmission (2005-06 Honda Odyssey 4-Door Minivan, 3.5L) EX-L Trim Package
Transtar Part Number: 30-BAC
Transtar now offers the 30-BAC. Remanufactured in the U.S.A. and with the latest OE upgrades, this popular FWD transmission is backed by the Transtar Seal of Quality. With Transtar's new Premium PLUS Protection (P3) warranty options, the 30-BAC comes standard with an 18-month/18,000-mile nationwide warranty, which can be upgraded to either a 36-month/100,000-mile or 36-month/500,000-mile nationwide warranty.
2012 Torque Converter Catalog
Transtar Part Number: TC2012
Transtar's 2012 Torque Converter catalog is the industry’s most robust converter diagnostic tool. Along with many new additions including more than 100 new torque converters covering applications up to 2012, a full year, make, model and engine size index, and technical service bulletins, this catalog features Transtar's Driveline Needs Assessment (DNA). A feature that is the first of its kind, Transtar’s DNA allows customers to easily locate all known solutions to common symptoms seen in a transmission – such as overheating, shudder, poor lock up, slippage and NVA.
FWD Transmission, Tag #BGRA (2005-06 Honda Odyssey LX/EX Models, 3.5L)
Transtar Part Number: 30-BAD
Transtar now offers the 30-BAD. Remanufactured in the U.S.A. and with the latest OE upgrades, this popular FWD transmission is backed by the Transtar Seal of Quality. With Transtar's new Premium PLUS Protection (P3) warranty options, the 30-BAD comes standard with an 18-month/18,000-mile nationwide warranty, which can be upgraded to either a 36-month/100,000-mile or 36-month/500,000-mile nationwide warranty.
Solenoid Rebuild Kit, AW55-50SN
Transtar Part Number: T-89428RF
This solenoid rebuild kit with bushings and new cans is for the AW55-50SN. The bushings in this kit are Teflon coated to resist sticking and wear, and the new cans have holes in the top to help keep debris from accumulating in the solenoid.
Installer for Aisin Warner Solenoid Bushings
Transtar Part Number: T-89428RK
Transtar offers the installer for Aisin Warner solenoid bushings! With this tool, you can install these solenoid bushings correct every time. It allows for both easy removal and installation.
Filter, 6L50 2010-Up (V6 Camaro)
Transtar Part Number: E104010C
Transtar part number E104010C is the latest addition filter to the GM 6L50/80/90 transmission family. It is used in the 2010-Up Chevrolet Camaro with the V6 engine. This filter is very similar to Transtar part number E104010A, except the spacer on the top side of the filter is .300" shorter. E104010C is the OEM filter.
2006-2007 Ford Fusion 2.3L 5-Speed FNR5 Transmission
Transtar Part Number: 48-MAA
Transtar now offers the 48-MAA. Remanufactured in the U.S.A. and with the latest OE upgrades, this popular FWD transmission is backed by the Transtar Seal of Quality.
L/U Shift Valve Kit, Honda/Acura
Transtar Part Number: S30741C-1
Now available is the L/U shift valve kit for various 5-speed Honda and Acura models. This kit will increase converter and lube pressure.
Filter, A4CF1/A4CF2 2006-Up
Transtar Part Number: A82010D
Transtar part number A82010D is the filter for the A4CF1 and A4CF2 transaxles. These transaxles are used in the 2006-Up Hyundai Elantra, 2006-Up Kia Spectra, and 2010-Up Kia Forte and Soul.
Check Valve Kit, Honda/Acura, Various 4 and 5-Speed Models
Transtar Part Number: S80741C-1A
Transtar offers a check valve kit for a variety of 4 and 5-speed Honda and Acura models. This kit, which is the second version of the S80741C-1, fixes poor cooler flow, TCC codes, and torque converter overheating. Ask your sales rep for all the applications.
2007-2009 Jeep Compass/Patriot, 2.0L FWD CVT
Transtar Part Number: 33-RAA
Remanufactured in the U.S. and to OE quality, this transmission is backed by the Transtar Seal of Quality and our 18-month/18,000 mile warranty, which can be upgraded to a premium 36-month/100,000 mile extended warranty.
Torque Converter, 2000-2007 GM 4L60E/4L65E
Transtar Part Number: GM92
Transtar has the GM92 torque converter, which fits the GM 4L60E/4L65E, years 2000-2007. It features 100 percent custom impeller hub replacement to correct build height issues.
Shift Correction Package (Superior) 5R55W/S/N
Transtar Part Number: S46165
Transtar part number S46165 includes an enhanced lube system, and fixes TCC and shift codes. One kit fits all!
Filter, TF60SN (VW 09M) 06-Up
Transtar Part Number: A15010C
Transtar has the sump filter for the VW 09M. The 09M is yet another variation of the Aisin TF60 transaxle. It is used in the 2006-Up VW Passat with a 3.6L V6.
5R110W Valve Body 03-Up
Transtar Part Number: P16740-1
This premium valve body is found in Ford SUVs, trucks and vans, years 2003-2010. Each valve body features a new Sonnax manual valve and end plug kit.
Toyota Celica 2000-2005 5-Speed FWD Manual Transmission w/1.8L Engine
Transtar Part Number: C56-A
Remanufactured in the U.S. and to OE quality, this popular transmission is in stock in multiple locations. The C56-A is backed by the Transtar Seal of Quality and our 18-month/18,000 mile national warranty.
Bushing Case (Driver's Side) 6F35/6T40
Transtar Part Number: 144064T
Now available is the Teflon coated case bushing for the 6F53 and the 6T40. This bushing is longer than the OE to prevent failure.
1996-2000 Honda Civic 5-Speed Front-Wheel Drive Manual Transmission (1.6L)
Transtar Part Number: S40
Transtar now offers the S40. Remanufactured in the U.S.A. and to OE quality, this transmission is in stock in multiple locations for on-time delivery. Our units are backed by Transtar’s 18-month/18,000 mile national warranty with extended 36-month/100,000 mile warranty availability.
Filter, Ford 6R80 Shallow Pan 2011-Up
Transtar Part Number: 95010G
Transtar part number 95010G is the OE filter for the Ford 6R80 rear-wheel drive with a shallow pan. It has a .275" fluid pick-up compared to a .875" fluid pick-up on the deep pan filter. It is used in 2011-Up Navigator, Expedition, F150, and Mustang models.
Tool Bit / Mortorque Spiral Driver
Transtar Part Number: T-1550A
Now available is the tool bit / mortorque spiral driver for use on the second design bell housing bolt for the 4L60/70E series. This will replace the T-1550 (T-50 Plus) torque driver used on the first design bell housing bolt.
Sonnax SmartShell
Transtar Part Number: S74624SS
The Sonnax SmartShell is the first and only upgrade to prevent damage to the 4L60 rear planetary assembly, as well as provide a reinforced shell. This shell includes an improved and strengthened shell, bearing assembly, and custom race. If you want to get a closer look at this one-of-a-kind SmartShell, you will find a link to a video on the homepage.
Master Kit with Steels, GM 6L50 2007-Up (With Bonded Clutch Pistons)
Transtar Part Number: 104006C
Transtar part number 104006C is a master rebuilding kit for the GM 6L50 transmission. It contains a Transtec overhaul kit, all the OE bonded clutch pistons, OE Borg Warner frictions, and all the steel plates necessary to rebuild the unit.
2002-2004 Saturn Vue CVT Transmissions With 2.2 Liter Engine (FWD and AWD)
Transtar Part Numbers: 33-WAA and 33-WAB
Transtar now offers the 33-WAA and 33-WAB. Remanufactured in the U.S. and to OE quality, these units come equipped with all of the OE updates and are shipped with CVT fluid. These units are backed by Transtar’s 36-month/100,000 national warranty.
GM TH350/350C Intermediate Outer Sprag Race
Transtar Part Number: A44663HD
This intermediate outer sprag race for the GM TH350/350C transmission is a Transtar exclusive. It features hardened bearing grade steel and precision manufacturing to ensure quality, and to provide a heavy duty replacement for the sprag race that is no longer available from the OEM. This is a newly manufactured item (a different color than other brands), and is ready for immediate installation.
Checkball Book Volume 2, Domestic
Transtar Part Number: CBDOM-2
Now available is the ATSG tech book showing checkball locations for domestic applications, including the new 6-speeds.
Toyota Corolla FWD 5-Speed Manual Transmission, 1.8L Engine, 2003 - Up
Transtar Part Number: C-56C
Transtar now offers the C-56C. Remanufactured in the U.S. and to OE quality, this popular transmission is in stock in multiple locations. Our units are backed by Transtar’s 18-month/18,000 mile national warranty with extended 36-month/100,000 mile warranty availability.
Filter, Ford 6F35 2008 - Up
Transtar Part Number: 144010A
Transtar part number 144010A is made by Filtran, the OE supplier of the 6F35 filter. This 6-speed front-wheel drive transaxle is used in various Ford and Mercury models, and the Mazda Tribute beginning in 2009.
Servo Installer CD4E
Transtar Part Number: T-9600
Transtar now stocks the T-9600. This tool makes removing the servo cover on a CD4E easy. It can be used with the transmission in the vehicle or on the bench.
Master Kit with Steels, VW 02E DCT 2003-Up
Transtar Part Number: 25006
Transtar part number 25006 contains all the sealing components, friction plates, and steel plates to overhaul the VW 02E Transaxle. This unit is called a "dual clutch" or a "direct shift" gear box. It is a 6-speed transaxle that is configured like a standard transmission, but the shifting and clutch function is all done electronically. It has a wet clutch consisting of two clutch packs in place of the normal clutch set up on a standard transmission. This unit is found in various Audi and VW models beginning in 2003.
AW55-50SN Valve body, Saab/GM, B or C Code, 2005-Up
Transtar Part Number: D89740B
Now available is the new OEM valve body for the AW55-50SN transmission - Saab and GM applications, 2005 and up. This valve body features the dome-type S2 solenoid and comes with the B5 spring. The ID codes are B or C.
1996-2000 Honda Civic 5-Speed FWD Standard Transmission with 1.6 Liter Engine
Transtar Part Number: S40
Transtar now has available the S40. Remanufactured in the U.S. and to OE quality, this popular Honda transmission is in stock in multiple locations. Our units are backed by Transtar’s 18-month/18,000 mile national warranty with extended 36-month/100,000 mile warranty availability.
GM 6F35 2-6 Piston 2008-Up
Transtar Part Number: D144546
Transtar now stocks the 2-6 position piston for the GM 6F35 transmission, years 2008 and up. This piston is a new OEM product and is ready for immediate installation.
Filter, 6T40/45 2008-Up
Transtar Part Number: E144010
Transtar part number E144010 is made by Filtertek, the OE supplier for the 6T40 filter. The 6T40/45 is a 6-speed front-wheel drive transaxle used in various GM vehicles beginning in 2008.
High Voltage and Leather Cover Gloves
Transtar Part Numbers: M467A (Medium), M467B (Large), M467C (XL), M467D (XXL), M467E, (Medium), M467F (Large), M467G (XL), M467H (XXL)
Transtar carries high voltage gloves for use on hybrid and electric vehicles. These gloves (M467A-D) are rated at 1000 AC volts and 1500 DC volts. The M467E-H are leather cover gloves to protect the rubber gloves from cutting. Quantities are limited!
2007-2008 Dodge Caliber 2.0L with CVT Transmission
Transtar Part Number: 33-RAA
Transtar now has available the 33-RAA. Remanufactured in the U.S. and to OE quality, this CVT transmission is in stock in multiple locations. Our units are backed by Transtar’s 18-month/18,000 mile national warranty with extended 36-month/100,000 mile warranty availability.
Detent Ball Bore Repair Torqueflite RWD 62-Up
Transtar Part Number: T12749
This detent ball bore repair kit from Transgo fixes three transmissions and requires no special tools.
2002-2006 Mini Cooper with 1.6 Liter Engine
Transtar Part Number: 33-ZFA
Transtar now has available the 33-ZFA. This unit is a CVT and is direct from ZF - so it will include all OE updates. Our units are backed by Transtar’s 18-month/18,000 mile national warranty with extended 36-month/100,000 mile warranty availability.
Chrysler 8.25-Inch Differential Bearing Kit 2005-2010
Transtar Part Number: 722H004
Transtar now stocks the differential bearing kit for the Chrysler 8.25-inch rear axle unit. This kit is for the Jeep Grand Cherokee - WK type. This kit includes pinion and side gear bearings, a pinion seal, and a crush sleeve.
Master Kit with Steels, RE0F10A (JF011E) 07-Up
Transtar Part Number: 33006N
Transtar kit 33006N contains all the gaskets, seals, rings, frictions and steel clutch plates necessary to rebuild the transaxle. The frictions are the OE Dynax plates. RE0F10A is the Nissan designation and JF011E is the Jatco designation for this CVT. This unit is used in the following vehicles: Dodge Caliber 07-Up, Jeep Compass and Patriot 07-Up, Mitsubishi Lancer and Outlander 08-Up, Nissan Sentra and 4-cylinder Altima 07-Up, and Nissan Rogue 08-Up.
Pump Alignment Tool - 6L80E
Transtar Part Number: T-46664
This pump alignment tool for the 6L80E takes the guess work out of aligning the pump to the bell housing.
Filter, 6L80 Shallow Pan, 2008-09
Transtar Part Number: E104010B
This filter from Filtertek, an OE supplier, is very similar to Transtar part number E104010A. One difference is this filter has a shorter outlet pipe. The total height of E104010B is approximately 5 3/4" - compared to 6 5/16" on the E104010A.
2002-2003 VW GTI 1.8 Liter, Turbo Charged 5-Speed 09A (JF506E) Reman Unit
Transtar Part Number: 98-AAJ
Transtar now has available the 98-AAJ with OE updates. This transmission is not only difficult to build, it is hard to find. Our units are backed by Transtar’s 18-month/18,000 mile national warranty with extended 36-month/100,000 mile warranty availability.
Ford 5R110W Oil Pump Assembly, 2005-2007
Transtar Part Number: P16500A
This Recon rebuilt oil pump assembly is for Ford 5R110W applications 2005-2007, but also retrofits to 2003. It features a refaced pump body and stator, polished sealing ring grooves, 100 percent bushing replacement, new pump gears, a new front seal, the Sonnax TCC control valve and sleeve, and the Sonnax oversized pressure regulator valve kit. This Recon pump also has all pump bolts torqued to OEM specifications so that this oil pump assembly is ready to install.
Torque Converter Check Valve Kit - Various 4 and 5-Speed Hondas
Transtar Part Number: S80741C-1
Transtar now stocks the torque converter check valve kit. This kit helps prevent torque converter overheating, TCC codes, and poor cooler flow.
ZF 5HP24 / 5HP24A Position A Clutch Retainer and Input Shaft, 1995-Up
Transtar Part Number: A139554A
This A position clutch retainer and input shaft for ZF 5HP24 and 5HP24A units, 1995 and up, is now in stock. This is a direct replacement for the often replaced OEM product, and is a Transtar exclusive.
2005/2006 Dodge Sprinter, 2500 or 3500 Model with 2.7, 5-Cylinder Diesel Engine
Transtar Part Number: 78-AAA
Transtar offers the complete 722.6 Mercedes transmission. Our units are remanufactured to OE specifications and backed by Transtar’s 18-month/18,000 mile national warranty with extended 36-month/100,000 mile warranty availability.
Master Kit with Steels, Aisin TR60SN (09D) 2003-Up
Transtar Part Number: 59006
The Aisin TR60SN, also known by the Volkswagen designation of 09D, is a 6-speed rear-wheel drive automatic transmission. It is used in Porsche Cayenne 2003-Up, VW Toureg 2004-Up, and Audi Q7 2007-Up. Transtar part number 59006 master kit contains all the gaskets, seals, rings, friction plates, and steel plates required to overhaul the transmission. Also available is a master kit without steel plates, Transtar number 59004.
Valve Pressure Regulator, Various Honda/Acura 4 and 5 Speeds
Transtar Part Number: S80741P-1
This valve pressure regulator from Sonnax helps prevent converter overheating.
GM 7.25" Independent Front Suspension 4x4 Differential Disconnect Assembly 01-08
Transtar Part Number: 741E-2
This differential disconnect assembly for the GM 7.25" independent front suspensions is now available for 4x4 Envoy and Trailblazer models, years 2001 through 2008. This assembly contains new OEM components and features a new shift actuator pre-installed. This is a complete assembly and is ready for immediate installation.
Bonded Valve Body Plates, ZF6HP26/6R60/75/80 2002-Up
Transtar Part Numbers: 95320/A/B/C/D/E
Transtar now stocks the bonded valve body plates for the ZF6HP26/6R60/75/80. These units do not use valve body gaskets, but the seperator plates have bonded rubber tracks that seal between the fluid passages in the valve body and case. There are several different plates based on model. The original plates have an ID number (i.e. 1068-327-141 or A035/B035) stamped on them. The correct Transtar number can be determined by this ID number.
2002-2007 Nissan Murano CVT Remanufactured Transmission Units - AWD or FWD
Transtar offers OE-quality CVT units for those hard-to-find Nissan Muranos. Units are backed by Transtar’s 18-month/18,000 mile national warranty with extended 36-month/100,000 mile warranty availability.
Detent Insulator w/Push In NSS 42-48RE 01-Up
Transtar Part Number: A22993D
Transtar offers the plastic insulator that commonly breaks on the detent lever. This detent lever is not available separate from the dealers - you have to buy the valve body.
Transfer Case Overhaul Kit, Borg Warner 4493, 2007-Up
Transtar Part Number: TSK4493
Transtar now carries the Transfer Case Overhaul Kit for the Borg Warner 4493, which covers application years 2007 and up. This gasket and seal kit features all sealing components for the BW4493.
Filter, Allison 1000/2000 Deep Pan 2010-Up
Transtar Part Number: 121010C
Allison introduced this filter in 2010 to improve the fluid flow capacity. This filter has a larger body and more surface area of the filter media than the previous filter, and will retro-fit back to 2006 for all models with GEN 4 controls.
2005 Volkswagen New Beetle Remanufactured Transmission (09G/TF60SN)
Transtar Part Number: 15-BAC
Remanufactured to OE specifications, this unit includes a new OE valve body, oil cooler and oil.
Transgo Lube Kit
Transtar Part Number: T80168
Transtar offers a Lube Kit from Transgo that fixes converter overheating on Honda Odyssey and Acura 3.2TL, 98-04. One kit fixes three transmissions.
Filter, Allison 1000/2000 Shallow Pan 2010-Up
Transtar Part Number: 121010B
Allison introduced this filter in 2010 to improve the fluid flow capacity. The filter has a larger body and more surface area of the filter media than the previous filter. This filter will retro-fit back to 2006 for all models with GEN 4 controls.
Saturn Vue - 2.2 Liter OE CVT Transmission 2002 -2004 FWD
Transtar Part Number: 33-MAA
This is an OE remanufactured CVT transmission that is supplied with OE fluid. This unit is backed by Transtar’s 18-month/18,000 mile national warranty, which covers replacement of the unit and labor based on the Transtar Complete Unit Warranty program.
2011 Standard Transmission and Transfer Case Parts Catalog
Transtar Part Number: ST2011
Transtar's 2011 Standard Transmission and Transfer Case Parts Catalog is now available. This industry leading comprehensive catalog features line drawings and components for nearly 100 standard transmission units and approximately 40 transfer case units. Ask your sales rep for your copy today, or click on the catalogs tab and you can view or download it!
AFL Valve Repair Kit 4T65E 97-Up
Transtar Part Number: A84741L
Transtar offers the AFL valve repair kit for the 4T65E from Superior Transmission Parts. This kit does not require any additional reamers.
Chrysler 68RFE Low Sprag & Race Kit 2007-Up
Transtar Part Number: A72642BK
Transtar now stocks the Low Sprag & Race kit for the Chrysler 68RFE for years 2007 and up. This Borg Warner kit includes the low sprag, inner race, and outer race.
In-Line Filter, 5R110 2008-Up
Transtar Part Number: 16013B
This complete filter assembly is the OEM in-line filter for 2008-Up 5R110 transmission. It includes the sealed metal housing and differs from the 2003-07 replaceable paper cartridge filter because it must be replaced as a whole assembly.
Filter, 6L45 2006-Up
Transtar Part Number: 104010
This sump filter for the GM 6L45 transmission is used in various 2006-Up BMW vehicles. This is the OEM filter made by Filtran.
Filter, Subaru 5EAT 2005-Up
Transtar Part Number: A63010B
This is the sump filter for the Subaru 5-speed automatic transmission used in various 2005-Up Subaru models. It is a metal screen that bolts to the valve body.
2003 -2004 Audi 01J CVT
Transtar Part Number: 33-TAB
Remanufactured with a new OE valve body and TCM, this unit is backed by Transtar’s 18-month/18,000 mile national warranty with extended 36-month/100,000 mile warranty availability.
CFT30 Transmission Torque Converter - 2005-2007 Ford Five Hundred AWD
Transtar Part Number: FM3301
The FM3301 torque converter fits the 2005-2007 Ford Five Hundred and Freestyle/Mercury Montego with AWD CVT transmissions. The converter has a unique impeller hub with one pump drive tab and is mounted with four studs to the flexplate.
Master Kit with Steels, Honda Civic 2006-Up (w/ Bonded Piston)
Transtar Part Number: 30006E
Transtar Master Kit 30006E contains a Transtec overhaul kit, Raybestos Honda GPX friction plates, and all the steel plates. It also includes the OEM bonded Low clutch balance piston, or retainer. Also available is Transtar part number 30004E, which is the same kit without the steel plates.
Nissan RE0F09A CVT Drive Belt 2003-Up
Transtar Part Number: D33700G
Transtar now carries the new OEM CVT Drive Belt for the Nissan RE0F09A transmission. This item is a direct replacement CVT Drive Belt for RE0F09A application years 2003 and up.
62TE Torque Converter, 2007-09 Chrysler T&C / Dodge Grand Caravan / VW Routan
Transtar Part Number: CR1320
This converter is similar in markings to earlier 604 style converters. The bolt pattern of 4 equally spaced 10mm x 1.5 threaded pads is similar to earlier designs as well. This converter can be identified by its shorter overall height of 4.150" - roughly 0.750" shorter than the earlier model year 604 converter. Converter cores may have the OE part numbers still legible. The last five digits are 520AA, 520AB, 556AA, 556AB, and 556AC.
Pump Bushing, 350/400/PG/AT540, Teflon Coated
Transtar Part Number: 44034T
Transtar now has the pump bushing for the 350, 400, Powerglide, and AT540. This pump bushing is teflon coated and will reduce hub and bushing wear.
2001-Up Heavy Duty GM Transfer Case
Transtar Part Number: NP263XHD
Transtar's 2001 and Up Heavy Duty GM Transfer Case is built to OE specification. This unit is backed by Transtar’s 18-month/18,000 mile national warranty with extended 36-month/100,000 mile warranty availability.
Reaming, Drilling and Tapping Fluid
Transtar Part Number: M465BT
Bio-Tap helps prevent galling and seizing. This fluid from Lubegard also improves tool performance and extends tool life.
Master Kit with Steels, AS68RC 2007-Up
Transtar Part Numbers: 99006 & 99004
Transtar number 99006 is a master kit with steels for the AS68RC. This is a 6-speed automatic RWD transmission manufactured by Aisin Seiki. It is used in 2007-Up Dodge 3500 trucks and called AS68RC. It is also used in Isuzu NPR and Mitsubishi Fuso trucks and referred to as the A465 in those applications. Also available is a master kit less steels, Transtar number 99004.
Reverse or D Position Retainer & Center Support, 2000-2006
Transtar Part Number: A129550D
The Aftermarket D position retainer and support (ZF 5HP19FL/A, ZF 5HP19FL, and 5HP19FLA), model years 2000 to 2006, is now available. This retainer is a direct replacement for the OEM retainer.
New PIG Form-A-Funnel
Transtar Part Number: T-18609
Transtar offers the Form-A-Funnel from New PIG. This funnel diverts oil around obstacles for no-mess oil changes and creates a leak proof seal around filters or drains. You can reshape and reuse the Form-A-Funnel thousands of times and it’s easy to clean and store.
Filter, AS68RC 07-Up
Transtar Part Number: A99010
A99010 is the main sump filter for the AS68RC transmission, also called A465. This transmission is a 6-speed automatic made by Aisin. It is used in 2007-Up Dodge 3500 trucks, Mitsubishi Fuso trucks, and Isuzu NPR trucks.
Valve Body End Plug Kit, Toyota/Lexus U140-U241E
Transtar Part Number: A27741A-6
This valve body end plug kit fixes codes, slips, flairs, bumps and bangs from pressure loss of the OE plugs.
Ford CD4E Forward and Direct Clutch Drum, 4 Direct Clutch Type, L1998-Up
Transtar Part Number: A96554CA
The Aftermarket drum for the Ford CD4E 2.5L V6 engine applications, model years late 1998 and up, is now available. This drum is a 4 Direct Clutch type when utilizing 0.079" thick steels, and can additionally be utilized in 4 cylinder engine applications.
Ford 5R55N/W/S Overdrive Planetary w/28-tooth pinion gears, 2002-Up
Transtar Part Number: A46580A
The Aftermarket Planetary for the Ford 5R55N/W/S applications has 28-tooth pinion gears and mates to the 38-tooth sun gear (Transtar Part Number D46610A). This high quality replacement part has the electric pickup, and features OEM bearings.
Plastic Cage Sprag for the 4L60E/70E
Transtar Part Number: A74658D
Borg Warner is now Transtar's OE supplier for the input sprag. This replaces the SKF brand.
Filter, TF60SN (VW 09G) 2005-Up (Raised inlet)
Transtar Part Number: A15010A
A15010A is the 2nd design filter used in the VW 09G transaxle. It is used in some 2005-Up models. The inlet on the bottom of the filter is raised up to provide a deeper pick up. This raised inlet differentiates this filter from the 1st design filter, A15010, which has a flat inlet on the bottom.
A604 and A606 Converters with Grooved Friction Material (EMCC1)
Transtar Part Numbers: CR0621 and CR0923
Now available for your 2003 and newer Chrysler passenger car applications, requiring EMCC1 friction material, are the CR0621 and CR0923. The CR0621 is for A606 applications and the CR0923 is for the A604 applications. Chrysler EMCC1 material is also referred to as "grooved" material. As these vehicles are calibrated from the factory to work with the EMCC1 material, it is necessary to install either the CR0621 or CR0923 to prevent chatter/judder during clutch apply.
Aisin Warner OEM Valve Bodies
Transtar Part Numbers: D89740C, D89740CA
New Aisin Warner OEM valve bodies for the AW55-50SN Nissan applications. D89740C (31705-8Y00B) is for Nissan applications covering years 2003 to 2005. D89740CA (31705-8Y00A) is for Nissan applications covering August 2005 to June 2006. These regularly replaced items are new OEM and include all electronics and solenoids.
Dodge Ram 46RE/46RH Heavy Duty Converter with Billet Cover
Transtar Part Number: CR94L-S1
With the addition of a billet cover, this converter is ready to work when you are. Reduced deflection of the friction surface during apply allow this billet cover converter to transmit torque through the driveline more efficiently. This converter has a lower stall optimized for the 5.9L V8 trucks, and can be used in 5.2L and 5.9L gas applications with a 90 degree bolt pattern.
End Plug Kit ZF6HP19/24/26/30/6R60/75/80
Transtar Part Number: A95741A-6
Leaking end plugs can cause all sorts of problems. Use the end plug kit to ensure the best rebuild possible.
Filter, U660E 2007-Up
Transtar Part Number: A47010
This filter is used in the U660 transaxle. This transaxle is a 6-speed front wheel drive transaxle found in various Lexus and Toyota models beginning in 2007.
Linear Solenoid Kit (3 Linear Solenoids with Bracket) AW55-50SN 01-Up
Transtar Part Number: A89428K
Why take the chance of used solenoids or trying to take apart and clean used ones? Why use a rebuilt when new ones are available? This kit includes all 3 linears and a bracket so it will accommodate all design levels.
Filter, 4L60E Auxiliary Pump 05-07 Partial Hybrid (M33)
Transtar Part Number: 74010H
In order to save fuel, some GM trucks and SUV's from 2005-07 had a feature that turned off the engine at stops and re-started it at take off. The 4L60E in these vehicles has an electric pump that maintains fluid pressure while the engine is stopped. 74010H is the filter for this electric pump. The pump and filter are accessible when the transmission pan is removed.
Remanufactured Ford 4R70W Planetary Geartrain 1992-Up
Transtar Part Number: R76583B
This geartrain includes a rebuilt and welded planetary, sun gear, ring gear, and sun gear shell. It fits all 4R70W applications with 31 or 38-tooth sun gears, when used as a kit.
Nissan RE0F09A CVT Pulley and Drive Belt Kit 2003-Up
Transtar Part Number: U33710GK
Transtar now stocks complete Nissan RE0F09A CVT Pulley and Drive Belt Kits found in Nissan Murano SUV's for model years 2003 and Up. This kit includes complete drive and driven pulleys and the drive belt.
Filter Kit (45RFE/68RFE 99-Up 2WD), Filter Kit (45RFE/68RFE 99-Up 4WD)
Transtar Part Number: 72011AF and 72011BF
In addition to the usual sump filter, seal and pan gasket, these kits also contain the cooler return spin on filter. Since the spin on filter is also inside the pan, it makes sense to replace both filters while the pan is off for a service. 72011AF is for the shallow pan and 72011BF is for the deep pan. Both filters in each kit are the OE filters.
Solenoid Governor Pressure (Borg Warner design ) Chrysler 42/44/46/47/48RE
Transtar Part Number: 12432A
This solenoid governor pressure will not flood out at increased line pressures. It can be used in modified and high performance units, as well as stock units.
Toyota U660E Complete Valve Body with Solenoids 2008-Up
Transtar Part Number: D47740
Transtar now carries the complete valve body for the latest Toyota 6 speed transmission, the U660E. This is an OEM valve body, includes all 7 solenoids, and is ready for immediate installation in vehicles 2008 and Up.
ZF 5HP19FL Converter (Audi / Volkswagen)
Transtar Part Number: AU21
This converter fits the 1997-1999 Audi A8 Sedan with the 3.7L engine. The converter will have an ink stamp code of "J28" with three mounting pads on the cover. This unit is used exclusively with the 1060-030-006 transmission spec number / 01V 300 041F OE transmission number.
Shift Kit Transgo VW09G / TF60SN
Transtar Part Number: T15165
This kit reduces, prevents and corrects harsh shifts, cut-loose, rough coasting downshifts, slow pressure rise and TCC slip.
Master Kit with Steels & Bonded Clutch Pistons, GM 6T70/75 07-Up
Transtar Part Number: 124006
The 6T70 is a 6 speed front wheel drive transaxled that was developed in a joint venture with General Motors and Ford. It is used in various GM vehicles beginning in 2007. Transtar kit 124006 contains a Transtec overahaul kit, all OEM frictions, steel plates, and all of the OEM bonded clutch pistons. 124004 is also available. It contains the same components except for the steel plates.
2002-2004 Saturn Vue CVT Units - AWD & FWD
Transtar Part Number: 33-MAA & 33-MAB
Remanufactured to OE quality from the OE remanufacturer, Saturn CVT Units are backed by Transtar’s 18-month/18,000 mile national warranty. This product will allow shops that would normally turn away this unit due to parts availability or technical knowledge to now accept the job.
Dodge Ram 1994-2007 47RH/47RE/48RE Cummins Diesel Triple Disc Torque Converter
Transtar Part Number: CR70X-S2
Now in stock nationwide is a Recon designed and developed replacement torque converter for the 1994-2007 5.9L Cummins equipped Dodge Ram 2500 and 3500 applications. With patent pending features from top to bottom, this converter is built to work perfectly in stock and moderately modified engine applications. The holding power of this converter is twice that of a stock converter, with a slightly lowered stall over a stock converter. Converter comes complete with custom mounting bolts to fasten the new converter to the flexplate.
Honda BYBA 5 speed 3rd Clutch Piston Kit, 2002-2004
Transtar Part Number: A30963AK
Transtar stocks the new aftermarket 3rd Clutch Drum Piston Kit for the Honda BYBA 5 speed transmission, model years 2002 to 2004. This kit for the 135MM O.D. type drum includes the 20 tooth type piston, piston retainer, retainer spring, and snap ring.
Filter Kit, GM 2ML70 Hybrid 2008-Up
Transtar Part Number: 174011
This kit contains two sump filters and the filter seals. The large filter is for the main pump and the small filter is for the auxiliary pump. The auxiliary pump is an electric pump that runs when the gas engine is not running. The 2ML70 is used in some 2008-up Tahoe and Yukon SUV's and 2009-Up Silverado and Sierra trucks.
SNAP RING PLIERS 6L80/90 / ZF6HP26 / 5L40 / 6R60 /80 / 6R140
Transtar Part Number: T-6800
The center support snap ring in these units are very hard to get out without damaging the case on these late model units. The pliers make it a breeze.
Torque Converter - 2007-2008 Dodge Ram 6.7L Cummins Diesel with 68RFE
Transtar Part Number: CR7201
68RFE torque converters are now in stock in warehouses nationwide. The 68RFE converter can be distinguished from the 48RE design by the impeller hub (68RFE has four flats instead of two). All CR7201 converters include the OE style twin-plate clutch design.
Master Kit with Steels, Ford/Mazda FNR5 2006-Up
Transtar Part Number: 48006EA
The FNR5 is a 5 speed version of the 4F27E. A reduction section was added to the 4F27E to provide an additional forward speed. The FNR5 is used in the Ford Fusion, Mercury Milan, Mazda 3, and Mazda 6 beginning in 2006. 48006EA contains all OEM Dynax frictions. All the bonded clutch pistons were not available initially, so this kit does not include the pistons. A kit with pistons will be added soon.
Pin Extender Reverse Servo 400/4L80E
Transtar Part Number: T34913
No need for selective pins, use the extender and grind to size.
Ford 5R110W Pump Gear Set
Transtar Part Number: 16530
Transtar now carries the Pump Gear Set for the Ford 5R110W transmission. This is an OEM product and is ready for immediate installation in pump assemblies 2003 and Up.
Seals, Intermediate/Direct Feed E4OD/4R100 89-Up (Sonnax)
Transtar Part Number: S36344
Stop loss of apply fluid between the case and center support.
Chrysler NAG 1/Mercedes 722.6 input position F1 sprag, 2006-Up
Transtar Part Number: A78658A
Transtar now stocks the input position F1 sprag for NAG 1/722.6 units in model years 2006 and up. This Borg Warner 20 element one-way clutch has 2 end caps and an inner diameter of 23.46 mm. This sprag is known as the "wide type" as it has an inner diameter 2 mm wider than the earlier "narrow type".
9 New Honda GPX Friction Plates
Transtar Part Numbers: R90100, R80114E, R30103, R80100AB, R80104, R30103A, R30104, R80106, R80108CA
Transtar now carries Raybestos GPX friction plates engineered specifically for Honda applications.
Chrysler A727 / A518 transmission oil pan, "deep" type (3.150" deep)
Transtar Part Number:A22765B
Transtar now carries an aftermarket replacement transmission oil pan for Chrysler A727 and A518 applications years 1990 and up. This often replaced pan is the "deep" type and is 3.150" deep and includes a magnet to help collect metal from the circulating transmission fluid. It is a direct product replacement for the OEM product.
2002-2004 Saab 9-3 and 9-5 Aisin Warner 55-50SN Torque Converter
Transtar Part Number: TO78
This converter is available nationwide. It can be identified by the 43A080 and / or 43A090 marking on the converter. The Precision part number cross reference is 6265. It has an 11.2" OD, 0.825" pilot diameter and a six pad mounting geometry with M8-1.25 threads.
Master Kit with Steels, GM 6L90 2007-Up
Transtar Part Number: 104006B
The 6L90 is the big brother to the 6L80. It is a heavy duty version of the 6L80. The differences are subtle, but enough to require different kits. The 6L90 has more clutches in each clutch pack, a larger rear seal, and a different configuration pan gasket. The 6L90 is used in 2007-Up GM 2500 and 3500 series trucks. Also available is 104004B master kit without steels.
Jack Buddy Jack Adapter
Transtar Part Number: T-3000
No more transmissions falling off the transmission jack. The Jack Buddy from Adapt-a-Case holds the transmission to the jack with longer arms and has a hold down strap for extra safety.
Adapter Cooler / Warmer Honda 00-Up
Transtar Part Number:A30998U
Adapts the OE cooler / warmer that is on the transmission for use with a stand alone cooler. A long cooler is recommended.
TF80/81SC B1 (2-6) Band, 05-Up
Transtar Part Number:N39024
N39024 is a double-wrap rigid band. It fits many applications in which the Aisin TF80SC and TF81SC transaxles are used. The TF80SC, also known as the AF40, is used in various 2006-Up Saab & Volvo models. The TF81SC, also known as the Ford AF21 or the Mazda AW6A-EL, is used in various 2005-Up Ford and Mazda models.
Saturn VT20/25 CVT Pulley and Drive Belt Assembly, 2002-05
Transtar Part Number:D33710JK
This item is the OEM CVT Pulley and Drive Belt Assembly as found in Saturn vehicles with the VT20 or VT25 transmissions for the years 2002 to 2005. The assembly includes the drive and driven pulleys, the multi-element belt, and the center case support.
Torque Converter - 2005-2007 Ford Mustang 4.0L
Transtar Part Number:FM4600
Now available for R&R, Transtar offers a torque converter for 2005-2007 Ford Mustang 4.0L applications. The converter has an 0.750" diameter pilot and four 10mm mounting studs. The overall diameter of the converter is 11.125" and has a "B" and "A" around the impeller hub. There is also a "4R3P" stamp on the cover.
TECKPAK PIN EXTENDER FOR THE REVERSE SERVO PIN ON TH400/4L80E TRANSMISSIONS
Transtar Part Number:T34913
No more looking for longer servo pins for both early and late style of pins. The pin extender allows you to customize your servo travel to specifications.
Master Kit with Steels, Chrysler 62TE 07-up
Transtar Part Number:132006
The 62TE is a 6-speed front wheel drive transaxle used in the 2007-Up Pacifica, Sebring, and Stratus. It's also used in the Avenger, Caravan, and Town & Country beginning in 2008. 132006 Master Kit contains the Overhaul Kit, OEM friction plates, and all steel plates to rebuild this unit. Also available is 132004 Master Kit without steels.
Mitsubish/Hyundai F5A51 valve body with 6 solenoids, 1997-up
Transtar Part Number:P82740-2
This late model premium rebuilt valve body for the F5A51 is for use in Mitsubish and Hyundai applications for years 1997 and up. The P82740-2 is a 6 solenoid type, features an updated pressure regulator valve, tested solenoids, and is fully functionally tested. This valve body has a 12 month/unlimited mileage warranty.
Master Kit with Steels, ZF4HP16 2002-up (with Bonded Clutch Pistons)
Transtar Part Number:189006D & 189004D
This master kit contains all the gaskets, seals, friction and steel plates, and bonded clutch pistons to overhaul the transaxle. Also in stock is the less steel kit, 189004D.
VB SEPERATOR PLATE 4R70/75E/W LATE 2000 - UP
Transtar Part Number:A76747C
Stops wear from the 2-3 accumulator piston spring retainer. The plate is zinc plated and extra thick. Superior # K092.
Torque Converter - 2007-2008 Dodge Ram 6.7L Cummins Diesel with 68RFE
Transtar Part Number:CR7201
Now available as an R&R, Transtar now offers a torque converter for the newest Dodge diesel applications. The converter can be distinguished from the previous 48RE design by the impeller hub design (four drive flats instead of two) and a unique stamped cover only seen with the 68RFE transmission. The converter includes the original equipment twin-plate clutch design.
Chrysler A618 / 48RE 5 clutch direct/front drum kit, 2003 and up.
Transtar Part Number:R22555CK
Transtar now carries a complete direct/front drum kit for the Chrysler A618 / 48RE transmission, years 2003 and up. This kit includes a remanufactured 5 clutch type direct drum, all 5 clutch frictions, all steels, the piston, springs and snap ring.
Torque Converter - Various Mitsubishi F4A51 / F4A5A
Transtar Part Number:KM17-6
This converter has six mounting pads and an integral 110-tooth ring gear. Code on the converter is 6g. Applications include 3.8L Endeavor and 3.0L / 3.5L Montero Sport. Cross reference to Precision 6464 / Dacco CT-32.
ACCUMULATOR PISTONS W/SEALS U140/150/240/250 96-UP
Transtar Part Number:A27932K
A SOLUTION FOR WORN BORES THAT RESULT IN BURNT CLUTCHES , SLIPS , FLARES , AND SHIFTING ISSUES . KIT INCLUDES A ACCUMULATOR BUDDY BORE BRUSH TO PREP THE BORE.
Filter, Subaru 4EAT 2005-Up
Transtar Part Number:23010C
The Subaru 4EAT had a change to the valve body and filter in 2005. The previous filter bolted to the valve body with 19 bolts. The new design has a round outlet with an o-ring that mates with the valve body, and it has 3 bolt tabs that fasten it to the valve body.
GM 8.5 / 8.6 inch Differential Bearing Kit, disc brake axle type, 1999 - 2005
Transtar Part Number:742G006A
Transtar now carries the differential bearing kit for the popular GM 8.5 and 8.6 inch disc brake type rear differential assemblies. This premium kit includes internal bearings, shims, seals, ring gear bolts, crush sleeve, pinion nut, gear marking compound, and silicone RTV gasket maker.
Filter, Ford 6R60/75/80 2007-up (1.5" Pick Up)
Transtar Part Number:95010E
This is the OE filter for these applications from 12/4/06 and up. It has a 1.5" pick up. 2006 models up to 12/4/06 used 95010D, which was a flat bottom filter.
Aisin-Warner TF81 (AF21) valve body with solenoids, 2005-up
Transtar Part Number:P39740-1
This late model premium rebuilt valve body for the Aisin-Warner TF81 or AF21 is for use in Ford and Mazda applications for years 2005 and up. The P39740-1 features all available Sonnax updates, tested linear solenoids, and are fully functionally tested. This valve body has a 12 month/unlimited mileage warranty.
NV4500 5th GEAR NUT REMOVER /INSTALLER DODGE / GM 5 SPEED 91-UP
Transtar Part Number:T-4500K
Will work on the units with the dampner design, will also work on Allison 1000 series 2 and 4 WD output nut.
Torque Converter - 2004-2007 Cadillac SRX 3.6L
Transtar Part Number:GM38
This converter appears on page 21 of the 2008 Torque Converter Catalog, and can be identified by the three rectangular mounting pads and 0.825" pilot diameter. Dacco cross reference is B24 0895 and Precision cross reference is 4248.
Master Kit with Steels, Chrysler 68RFE 2007-Up
Transtar Part Number:72006C
The 68RFE is a 6 speed rear wheel drive unit found in 2007-up heavy duty Dodge trucks. 72006C contains the overhaul kit, all OEM frictions, bonded clutch pistons, and steel plates to rebuild this unit. One sided frictions are used in the Underdrive, Overdrive, and Low Reverse clutch packs. 4 of the 6 clutch packs, Underdrive, 2nd, 4th, and Low Reverse, have bonded clutch pistons. These are all included in the kit.
Torque Converter - Various 2002-2005 Nissan 3.5L applications
Transtar Part Number: DA42L
This converter can be identified by observing the blade angle of the impeller along with the "LF" metal stamp on the cover. Dacco cross reference is DA-39L/S and Precision cross reference is 6751LS.
PISTON REAR SERVO W/HUMP 4L80E 96-UP
Transtar Part Number: A34912A
No more piston breakage, Transtar carries a billet aluminum servo replacement for 96-Up small pin design that was prone to breakage.
Master Kit with Steels, Ford CFT30 CVT 05-07
Transtar Part Number:33006L
Contains all the frictions, steels, gaskets, and seals to rebuild this unit. The CFT30 CVT is used in the 2005-07 Ford 500, Ford Freestyle, and Mercury Montego.
5R110W Torque Converters with Billet Covers
Transtar Part Number: FM160L-S1 and FM160M-S1
Now available from Transtar are heavy duty billet cover versions of the 5R110 gas and diesel torque converters. Durability is increased beyond the addition of a billet cover by adding a new LuK OE triple friction damper and heavy-duty thrust bearings on both sides of the stator assembly. All impellers and turbines are brazed for additional strength. Use the FM160L-S1 for all V10 and diesel applications, and the FM160M-S1 for 5.4L gas applications.
Nissan RE5R05A Premium Valve Dody
Transtar Part Number: P63740-5
This late model RE5R05A premium valve body is the 3rd design type containing tested solenoids and is both hydraulically and electronically tested for full functional capability. High ohm solenoid, late TCM type, 2003-up. The TCM is not included.
Honda Cooler/Warmer, bolts on top of transmission
Transtar Part Number: D30998, D30998A, D30998B
The coolers mounted on top of some Honda and Acura vehicles cannot be flushed properly so why take the change of contaminating you new rebuild? Transtar now carries the OE cooler warmer to protect your investment.
GM 5L40E Torque Converter, Cadillac SRX 3.6L, 2004-2007
Transtar Part Number: GM38
A new addition to our comprehensive torque converter line is the GM38. This converter is found in the 2004-2007 Cadillac SRX 3.6L application. Please call your sales rep today for pricing and availability.
Chrysler 48RE Sun Gear Shell, 2003-up
Transtar Part Number: A22622B
This aftermarket product is a cost-effective direct replacment item for the OEM product.
Allison 1000 C2 Clutch Powerpack , 2001-up
Transtar Part Number: A121100HPK
The C2 powerpack contains special red frictions and kolene steels that increase the number of clutches in the pack for added torque capacity for high performance and heavy duty applications.
Also available for the Allison 1000 are powerpacks for the C1 (A121108HPK), C3 (A121106HPK), and C4 (A121104HPK) clutches.
Dipstick Tools, Mercedes 722.6/Chrysler NAG1, 96-Up
Transtar Part Number: T-9336A / T-9336B / T-9336C
These tools are for the Mercedes and Chrysler transmissions without dipsticks. They properly checkthe transmission fluid level after a rebuild or fluid change.
ZF 5HP-19 Torque Converter, 1996-2003
Transtar Part Number: AU11
Now in stock for the ZF 5HP-19 series transmission is the AU11 torque converter. Found in several 1996-2003 Audi and VW applications with the 1.8L and 2.0L turbo engine, this converter has a slotted hub and 27 tooth spline. Codes that may be on the OE assembly are A33, B31, K28 and M28. Three mounting pads and a 0.629" diameter pilot will also indicate that this converter is what you're looking for. The outside diameter of this new converter is 10.875."
Ford 4F50N Sun Drive, 2001-Up
Transtar Part Number: A86618HA
Ford 4F50N Final Drive Sun Gear, 29 teeth, 5.25" long, for applications 2001-up. This aftermarket differential sun gear is a cost-effective substitute for the often-replaced OEM product.
Nissan RE0F09A Master Kit, 2003-Up
Transtar Part Number: 33006G
Master Kit with Steels & Bonded Clutch Piston, Nissan RE0F09A 2003-Up. This Transtar master kit contains all OEM gaskets and seals, frictions, steels, and bonded piston.
Aisin Warner Shift Kit,
Transtar Part Number: T89165C
This Shift Kit for the AW55-50SN reduces and prevents delay/bang drive engagement, 4-3 and 2-3 coast clunk, 2-3 and 3-4 cut loose, and TCC slip. Allows the builder to take apart and clean the linear solenoids.
Toyota U140 Series Valve Body, 1998-up
Transtar Part No. P27740-1
Transtar now carries the premium rebuilt valve body for the 2 wheel drive Toyota U140, U240, and U241 transmission series, years 1998 and up. The feature that identifies this as a 2 wheel drive version is that there is no lube orifice hole. The valve body has been rebuilt featuring the following Sonnax products: Oversized Pressure Regulator Boost Valve Assembly (57917E-08K), Clutch Apply Control Plunger Valve & Sleeve (57917E-05K), Lock-up Plunger & Sleeve (57917E-03K), and Solenoid Modulator Valve (57917E-13K). This valve body also features fully tested solenoids. Contact your Transtar sales representative for price and availability.
Toyota U140 Series Valve Body, 1998-up
Transtar Part No. P27740-2
Transtar now carries the premium rebuilt valve body for the all wheel drive Toyota U140, U240, and U241 transmission series, years 1998 and up. The feature that identifies this as an all wheel drive version is that there is a lube orifice hole. The valve body has been rebuilt featuring the following Sonnax products: Oversized Pressure Regulator Boost Valve Assembly (57917E-08K), Clutch Apply Control Plunger Valve & Sleeve (57917E-05K), Lock-up Plunger & Sleeve (57917E-03K), and Solenoid Modulator Valve (57917E-13K). This valve body also features fully tested solenoids. Contact your Transtar sales representative for price and availability.
Allison 1000/2000/2400 Trim Valve & Spring Kit
Transtar Part No. S121741WK
Transtar now carries the Trim Valves and Springs Kit for the Allison 1000, 2000, and 2400 series transmissions years 2002 and up. This Sonnax kit (37000-12K) addresses the issue of long shift duration which promotes premature clutch wear in heavy-duty applications. The kit includes A trim valve and spring, B trim valve and spring, and F trim spring. To use this kit, the valve body must be modified by using Transtar Part No. T-37000-TL12 (Sonnax Part No. 37000-TL12) which includes reamers for the A and B trim valve bores.
Aisin Warner 450-43LE Cutback Sleeve
Transtar Part No. 49741H-2
Transtar now carries the cutback valve sleeve for the AW 450-43LE transmission years 1998 and up. This sleeve only item (Superior Part No. K081) features an upgrade to hardened steel and requires no modification to the transmission.
Aisin Warner 450-43LE Cutback Valve & Sleeve Kit
Transtar Part No. 49741HK
Transtar now carries the cutback valve and sleeve kit for the AW 450-43LE transmission years 1998 and up. This Sonnax kit (94987-01K) addresses the issue of the engine stalling when the transmission is put into gear. This kit features upgraded materials and includes the valve, sleeve, end plug, spring, and one coiled spring pin. This kit is a direct replacement for the OEM product.
GM 4L80E Forward Clutch Drum w/ Ring Gear
Transtar Part No. A34554EA
Transtar now carries the new Aftermarket GM 4L80E Forward Clutch Drum with Ring Gear for years 1997 and up. This drum is the molded piston type and is a direct replacement for the OEM product (24234155).
Chrysler 42RLE Premium Rebuilt Valve Body 2003-up
Transtar Part No. P162740-1
Transtar now carries the Premium Rebuilt Valve Body for the Chrysler 42RLE transmission years 2003 and up. This product from VBX features a Sonnax converter regulator valve, the MLPS, and solenoid switch plugs. It does not come with the solenoid pack. This valve body is tested electronically and hydraulically to help guarantee that your job is completed and moving down the road. This premium product carries a 12 month/unlimited mileage warranty.
Contact your Transtar Sales Rep today for price and availability.
Ford AXODE / AX4S Valve Body Repair Kit
Transtar Part No. A86165E
Transtar now carries the Intelligent Service Package (TM) from RatioTek for the Ford AXODE and AX4S transmissions. This valve body kit features improved shift firmness with different spring selections, improved lube flow, and it includes a high quality bypass booster sleeve to restore correct torque converter clutch function, and restores main TV booster pressure function.
Aisin Warner 55-50 Lockup Relay Control Valve & Sleeve
Transtar Part No. S89741C
Transtar now carries the Lockup Relay Control Valve & Sleeve for the Aisin Warner 55-50 transmission. This item from Sonnax Industries, Inc. (59947-01K) is an upgraded aftermarket item that addresses the common occurrences of TCC Apply/Release problems, reduced torque converter pressure, overheated fluid, and bushing and solenoid failure due to wear. This drop-in replacement product features upgraded materials and tight tolerances to help prevent a reoccurrence of the original problems.
Aisin Warner 55-50 Lockup Control Valve & Sleeve
Transtar Part No. S89741CA
Transtar now carries the Lockup Control Valve & Sleeve for the Aisin Warner 55-50 transmission. This item from Sonnax Industries, Inc. (59947-03K) is an upgraded aftermarket item that addresses the common occurrences of TCC Apply/Release problems, torque converter failure codes, and burned out torque converters due to wear of the sleeve bore. This drop-in replacement product features upgraded materials and tight tolerances to help prevent a reoccurrence of the original problems.
Aisin Warner 55-50 Pressure Regulator Boost Valve & Sleeve
Transtar Part No. S89741F
Transtar now carries the Pressure Regulator Boost Valve & Sleeve for the Aisin Warner 55-50 transmission. This item from Sonnax Industries, Inc. (59947-07K) is an upgraded aftermarket item that addresses the common occurrences of delayed engagement, harsh/soft upshifts, and erratic reverse pressure due to wear. This drop-in replacement product features upgraded materials and tight tolerances to help prevent a reoccurrence of the original problems.
Aisin Warner 55-50 Solenoid Modulator Valve Capsule Kit
Transtar Part No. S89741LK
Transtar now carries the Solenoid Modulator Valve Capsule Kit for the Aisin Warner 55-50 transmission. This item from Sonnax Industries, Inc. (59947-09K) is an upgraded aftermarket item that addresses the common occurrence of lost of 3rd, 4th, or 5th gear, no TCC apply, low line pressure, delayed forward, 2-3 flare upshifts, and a 5th gear only condition due to wear in the valve bore. This drop-in replacement product includes the solenoid modulator valve, sleeve, spring, and 2 orifice plugs.
Aisin Warner 55-50 Oversized Pressure Regulator & Boost Valve Kit
Transtar Part No. S89741PK
Transtar now carries the Oversized Pressure Regulator & Boost Valve Kit for the Aisin Warner 55-50 transmission. This item from Sonnax Industries, Inc. (59947-12K) is an upgraded aftermarket item that addresses the common occurrence of wear at the pressure regulator valve bore which results in harsh or soft shifts, delayed engagements, torque converter apply/release problems, and late shifts. This upgraded item features enhanced materials and includes the pressure regulator valve & sleeve and the boost valve & sleeve. Note that this is NOT a drop-in replacement item. To install the S89741PK, the use of Transtar Part No. T-F-59947-TL12 (Sonnax Part No. F-59947-TL12) tool kit is required and includes a reamer, guide pin, and reamer jig. Also required is Transtar Part No. T-VB-FIX which is the valve body fixture.
Aisin Warner 55-50 Solenoid Relay Valve & Sleeve
Transtar Part No. S89741Q
Transtar now carries the Solenoid Relay Valve & Sleeve for the Aisin Warner 55-50 transmission. This item from Sonnax Industries, Inc. (59947-05K) is an upgraded aftermarket item that addresses the common occurrence of no TCC apply, shift concerns, harsh shift in all ranges, engine stall during engagement, B-5 clutch distress and no upshift after 2nd flare on 2-3 shift due to wear. This drop-in replacement product features upgraded materials and tight tolerances to help prevent a reoccurrence of the original problems.
Aisin Warner 450-43LE Wire Harness 1998-up
Transtar Part No. D49446
Transtar now carries the internal wire harness for the Aisin Warner 450-43LE years 1998 and up. This internal harness includes the connector and is OEM.
4L30E Shift Kit® 1991-2004
Transtar Part No. T24165E
Transtar now carries the Shift Kit® for the 4L30E transmission years 1991 to 2004. This Shift Kit® covers BMW, Isuzu, and Cadillac models. The kit helps to prevent or correct PWM torque converter burn-up, chronic low band failure, slips in reverse, 1st or 2nd, or direct clutch failure. The kit includes a precision center support circuit distribution bushing, a steel adaptor for easy bushing installation, and a caged input shuttle ball.
Mitsubishi KM Series / W4A32 Kickdown Band Drum (Shell)
Transtar Part Nos. D42622E, D42622H
Transtar now carries the OEM kickdown band drum (shell) for the Mitsubishi KM Series and F4/W4A32 transmission series years 1988 and up. These are carried in two different lug lengths. The D42622E has 3/4" long lugs. The D42622H has 1/2" long lugs.
VW 01M Shift Kit , 1995-2004
Transtar Part No. T75165
Transtar now carries the Shift Kit® from Transgo for the Volkswagen 01M applications, years 1995 to 2004. This kit includes the aluminum threaded end plug to replace the OEM plastic plug that typically breaks. The Shift Kit® helps to correct poor lockup, and poor 1-2 shifting.
Mazda JF506E Technical Manual
Transtar Part No. 98400A
Transtar now carries the Technical Manual for the JF506E from ATSG. This manual contains the procedures necessary to diagnose, overhaul and/or repair the Mazda JF506E transaxle. (Listed as 98400 in the Transtar Catalog)
Mazda JF506E Technical Manual, Updated
Transtar Part No. 98400B
Transtar now carries the Updated Technical Manual for the JF506E from ATSG. The JF506E transaxles are all similar in the teardown and assembly process, but the internal and external parts are different in the design and engineering area. This manual is designed to identify the engineering differences between the current models available at this time. (Listed as 98400C in the Transtar Catalog)
ZF 6HP26 Filter and Pan Assembly
Transtar Part No. 95010
Transtar now carries the Filter and Pan Assembly for the ZF 6HP26 transmission, years 2002-up. This filter is incorporated into one assembly with the plastic transmission pan. It comes with the molded rubber pan gasket included. Except for the fluid, this part number is all you need for a transmission service. This one-piece assembly is used in 6HP26 transmissions found in 2002-up BMW and Jaguar passenger cars.
Ford 6R60 / 6R75 Filter
Transtar Part No. 95010D
Transtar now carries the filter for Ford 6R60 and 6R75 transmissions, years 2005-up. This filter is made by SPX Filtran. The 6R60 is found in 2006-up Explorers. The 6R75 is found in the 2005-up Lincoln Navigator and 2007 up Ford Expedition.
Chrysler 45RFE 2nd/4th Clutch Housing
Transtar Part No. D72558
Transtar now carries the 2nd/4th clutch housing for the Chrysler 45RFE transmissions years 2005-up. In mid-stream 2005, several running changes were made to the Chrysler 45RFE series transmission. One of the changes involves the 2nd/4th clutch housing, D72558, and piston. As an assembly, the 2nd/4th clutch components will retrofit to 1999.
Chrysler 45RFE 4th Clutch Bonded Piston
Transtar Part No. D72961A
Transtar now carries the 4th clutch bonded piston for Chrysler 45RFE transmissions, years 2005-up. In mid-stream 2005 several running changes were made to the 45RFE series transmission. The changes involve the 2nd/4th clutch housing and pistons. The previous pistons had removable seals, whereas the new design pistons are bonded rubber. The 4th clutch piston, D72961A, will not retrofit back due to the seal cut of the early piston/housing. Therefore, the 4th clutch piston and housing must be used as a set, 1st or 2nd design.
Chrysler 45RFE Low/Reverse Housing
Transtar Part No. D72557
Transtar now carries the low/reverse housing for the Chrysler 45RFE transmissions. The low/reverse housing, D72557, will work on 1999-up models due to minor modifications. Frictions, steels, backing plate and low roller clutch are all unchanged.
Chrysler 45RFE Low/Reverse Bonded Piston and Spring
Transtar Part No. D72967A
Transtar now carries the low/reverse bonded piston and spring for the Chrysler 45RFE transmissions years 2005-up. The low/reverse piston and spring, D72967A, will retrofit to 1999, but only as a set. During the change to bonded piston, the return spring diameter was increased and will not work on the older aluminum piston. The D72967A currently contains the piston and spring.
Mitsubishi / Hyundai F4A41 / 42 / 51 Pump Body w/ Gears
Transtar Part No. D82510A
Transtar now carries the OEM pump body for the F4A41, F4A42, and F4A51 found in Mitsubishi and Hyundai applications. This pump body is the steel type and includes the pump gears.
GM 6L80 Technical Manual
Transtar Part No. 104400A
Transtar now carries the ATSG Technical Manual, Transtar Part No. 104400A, contains the procedures necessary to diagnose, overhaul, and/or repair the GM 6L80 6 speed transmission.
GM / Isuzu 4L30E Pump Stator, 4 valve type, w/ Gears, 2000-up
Transtar Part No. D24520EB
Transtar now carries the OEM Pump Stator for the GM and Isuzu 4L30E transmission, years 2000 and up. This is the popular 4 valve type pump stator, and includes the pump gears and the pump plate.
TranX 2000 Hyundai F4A/F5A Adapter
Transtar Part No. 12X205
Transtar now stocks the latest Hyundai Adapter from Zoom Technology Inc. This Hyundai Adapter is for use in testing the F4A and F5A transmissions. This item requires the use of the following items: Base Testing Unit Transtar Part No. TX2000 Testing Unit Update Transtar Part No. TX2006A Update Calibrator Transtar Part No. ZCAL
Saturn CVT Torque Converter
Transtar Part No. GM96
Transtar now carries a Recon Torque Converter for the Saturn VUE and ION with the VTi continuously variable transmission (CVT). This converter and transmission are found in the 2002-2004 Saturn VUE and 2003-2004 Saturn ION. The converter has three mounting pads with 10mmx1.25 threads, and has an outside diameter of 9.65”.
Mercedes 722.6 Master Kits with or without Steels, 2002-up
Transtar Part Nos. 78004C, 78006C, 78004D, 78006D
Transtar now carries the rebuilding kits for the Mercedes-Benz 722.6 transmission, years 2002-up. In kit years 1996 to 2001, the frictions for B1, K1, and K3 are 2-sided. In 2002, the frictions were updated to 1-sided frictions for the B1, K1, and K3 positions. “Light Duty” kits carry the 5.250” ID (smaller) K2 frictions, while the “Heavy Duty” kits carry the 5.450” ID (larger) K2 frictions. All 4 kits also include the B1 clutch bonded piston and the latex coated pump plate. In addition to Mercedes vehicles, these kits also cover various Chrysler vehicles that use the 722.6 (NAG1) transmission.
Transtar Part No. 78004C is the 722.6 Master Kit, Less Steels, Light Duty Kit, 2002-up. Transtar Part No. 78006C is the 722.6 Master Kit, With Steels, Light Duty Kit, 2002-up. Transtar Part No. 78004D is the 722.6 Master Kit, Less Steels, Heavy Duty Kit, 2002-up. Transtar Part No. 78006D is the 722.6 Master Kit, With Steels, Heavy Duty Kit, 2002-up.
Chrysler A604 (41TES) Pressure Transducer Switch, 2007-up
Transtar Part No. D92415
Transtar now carries the OEM Chrysler Pressure Transducer Switch for the 41TES version of the A604 transmission, years 2007-up.
Chrysler A604 (41TES) EPC Solenoid, 2007-up
Transtar Part No. D92431
Transtar now carries the OEM Chrysler EPC solenoid for the 41TES model of the A604 transmission, years 2007-up.
Chrysler A604 (41TES) EPC Solenoid Connector, 2007-up
Transtar Part No. D92444
Transtar now carries the OEM Chrysler EPC Solenoid Connector for the 41TES model of the A604 transmission, years 2007-up.
TranX 2000 GM 5L40E Adapter
Transtar Part No. 07X220
Now available from Transtar is the GM 5L40E Adapter for the TranX 2000 from Zoom Technologies. The TranX 2006A module (Transtar Part No. TX2006A sold separately) must be installed in the TranX 2000 for this adapter to function.
Toyota U241E RAV4 Medium Stall Torque Converter
Transtar Part No. TO75
Transtar now carries a Recon Torque Converter for the Toyota U241E Transmission RAV4 applications. This is a medium stall unit that can be identified by a stamp “16U” on the cover side of the converter. This converter has a 26 spline turbine, a 38 spline stator, and has six mounting pads with 9mm x 1.25 threads.
RE5R05A Master Kit with or without Steels, 2004-up
Transtar numbers 63004A, 63006A
These new RE5R05A kits cover the Nissan Titan full size pickup truck and the Nissan Armada and Infinti QX56 full size SUV’s. These models use 40 tooth vs. 50 tooth reverse frictions while using both thinner and different tooth configuration steel plates in the forward and low coast clutch. 63004A and 63006A compliment existing Transtar kits 63004 and 63006, which cover models other than the Titan, Armada, and QX56.
Chrysler A604 Conversion Connector, MLPS to Spade type
Transtar Part No. A92445E
Now available from Transtar is a specialty connector for the Chrysler A604 transmission. This connector adapts the round pin terminal (early MLPS) to the spade terminal (late MLPS).
GM 4L60E Valve Body Kit, Ratio Tek
Transtar Part No. A74165EA
Now available from Transtar is a new "Intelligent Service Package" Valve Body Kit from Ratio Tek for the GM 4L60E transmission. This valve body kit improves shift firmness, TCC slip codes, restores pressure regulator booster valve function, and eliminates the need to replace the TCC Regulator and Isolator valves as well as the Booster Valve and Sleeve assembly. Instructions are included.
Filter, Acura MDX 2003-06
This filter is now available for the Acura MDX 2003-06 (transmission codes MDKA, BDKA).
Transtar # 50801B, Axiom # A30010C
Additional Acura Applications for Honda Filter
In addition to being used in the Honda Civic HX 1996-00 (M4VA), this cooler return filter also fits the Acura MDX 2003-07 (MDKA, BDKA, BYFA), and the Acura RL 2005-07 (MJBA).
This round cartridge filter was first used in the 1996 Honda Civic HX with a CVT transaxle, and we cataloged it for the 1996-2000 Civic HX. This same filter is also used in the Acura applications listed above.
These additional applications have been added to the part description and will be reflected in the next catalog.
Transtar # 50800U, Axiom # A40013
E4OD / 4R100 Forward Clutch Drum
Ford E4OD / 4R100 forward clutch drum, 4 clutch pack type, 1989-98. Version with long center splines.
This aftermarket replacement item is an early version E4OD type drum with long center splines. This version was discontinued by Ford and replaced with a short center spline type, while retaining the same OEM part number. For the purposes of durability and strength, the industry prefers the long spline version. This drum fits and functions correctly in all E4OD and 4R100 applications from 1989-98.
Transtar # 73927, Axiom # A36554HA
(OEM ref. # E9TZ-7A360-AA, YC3Z-7A360-AA, F81Z-7A360-AA)
Master Kit, 5L40E 2001-up (All Wheel Drive)
BMW X3, 2004-06
BMW X5 3.0i, 2001-06
Cadillac SRX All Wheel Drive, 2004-up
Cadillac STS All Wheel Drive, 2005-up
This new Master Kit is for all wheel drive applications. It complements existing Axiom Master Kit # 134006, which is for rear wheel drive applications.
The difference between the two kits is the 2nd clutch and 2nd coast clutch. The AWD units have larger diameter clutches in these two clutch packs.
The new clutches for AWD are one-sided frictions, as are all of the frictions in the 5L40E transmission.
Transtar # K4100P, Axiom # 134006A
Master & Banner Kits, RE5R05A 2002-up
Master Kit less Steels (Except Armada, Titan and QX56) Transtar # K9300LS, Axiom # 63004
Master Kit with Steels (Except Armada, Titan and QX56) Transtar # K9300, Axiom # 63006
The above kits fit all models EXCEPT the Armada, Titan and QX56. These three models use different Reverse Brake frictions and steels, which are not available yet.
They also use different steels in the Forward (Axiom # 63128A) and Low Coast (Axiom # 63132A) clutch packs, which we do have available separately.
We will offer a kit for the other three models as soon as the Reverse Brake clutches become available.
5L40E 4WD Bonded Clutch Piston Kit
CD4E Forward Planetary
Honda/Acura Inline Cooler Filters
EPC Solenoids
E4OD/4R100 Int. Clutch
SK® TFOD-Diesel - Kit Upgrade
Ford 5R55W Servo Cover
TranX 2000 Update Processor
Honda 2nd & 3rd Pressure Switches
Ford 4R100 Race Conversion Kit
New Process Case Saver
ZF 5HP24 Piston
Ford 4R100 Inner/Outer Race Conversion Kit
ZF S5-47 Slider & Hub Kit
GM Transmission Guides
ATRA Technical Manuals
Chrysler A604 Geartrain, 1996-up, retrofits
Transtar Part No. A92583B
A604 Geartrain Kit, 1996-up (retros 1991-up) This geartrain kit features all aftermarket hard parts and 2 installed OEM bearings. The kit includes: 5 pinion gear rear planet with 1 1/8" shaft, Front planet. Overdrive clutch hub, 2-4 clutch hub with sun gear, Rear planet w/ ring gear, Rear planet sun gear. This kit replaces OEM # 5014200AA, 4377080, 4659618AB, 4799794, 4567439AB, 4659993

